The Science Media Centre has posted its rundown on Fonterra’s confirmation of Clostridium botulinum contamination of milk whey protein from the company’s Hautapu manufacturing facility and the Ministry for Primary Industries’ warning not to use certain brands of infant formula in New Zealand for fear of it containing the potentially harmful bacteria.
The Ministry of Health has so far received no case notifications of babies or infants with Clostridium botulinum in New Zealand.
The Science Media Centre points to more information about infant botulism, which can occur when an infant ingests the bacteria (here).
It has also collected expert commentary from –
Dr Siouxsie Wiles, HRC Hercus Fellow, School of Medical Sciences, University of Auckland, comments:
“C. botulinum is a Gram-positive bacterium, which cannot tolerate any more than trace amounts of oxygen. The bacterium produces spores which are very hard to kill and thus help the bacterium survive adverse conditions. C. botulinum is a worry because it can cause botulism, a rare but sometimes fatal illness.
“Botulism is caused by the ability of C. botulinum to produce several neurotoxins which prevent acetylcholine from being released from the motor nerve endings causing flaccid paralysis and symptoms of blurred vision, drooping eyelids, nausea, vomiting, diarrhea and/or constipation and cramps. In severe cases it leads to paralysis of the breathing muscles and causes respiratory failure.
“The toxins are produced when C. botulinum spores germinate and the bacterium starts to actively grow, which it can only do in an environment with no oxygen.
“There are three main forms of illness caused by C. botulinum:
Foodborne botulism, caused by consuming food or drink contaminated with botulinum toxins,
Infant botulism, where the gastrointestinal tracts of babies becomes colonised by C. botulinumspores before their protective gut microbes establish are established. This is why parents are advised not to give honey to children under the age of 1,
Wound botulism, when wounds become infected with C. botulinum spores.
“Botulinum toxin A is one of the most toxic substances known to man. One kilogram of it would be enough to kill the entire human population! Incredible then that this deadly toxin is voluntarily injected into the faces of millions in the pursuit of youth. They know it by its trade name – Botox. But it’s not just used for treating wrinkles, botulinum toxin A is also used to treat spasms, migraines, squints, excessive blinking and excessive sweating.”
Prof John Brooks, Professor of Food Microbiology, AUT, comments:
“Apparently, the source of the bacteria has been traced to a dirty pipe in a processing factory. If this is true, it’s a serious lapse in process control and obviously should not have occurred.
“The whey was made in May 2012 and it is unclear why the contamination has taken so long to come to light and why the company has been so slow to inform the government and the public. The company became aware of the contamination in March, but it was not until Wednesday 31st July 2013 that tests confirmed the presence of the bacteria.
“There are some possible explanations for the delay: third parties may have tested the product at some point in their own manufacturing operations and found it; the contamination levels may be very low, resulting in a requirement to test large amounts of product before the contaminants were found. Certainly, once the bacteria had been isolated, using modern methods,it should not have taken long to confirm the identification.
“It is not usual to test dairy products for the presence of Clostridium botulinum. When bacteria occur in a product at very low level and very infrequently, testing is ineffective in assuring safety and the cost is prohibitive. An Australian specification for whey protein concentrate does not mention Clostridia.
“The concern about the presence of C. botulinum is real and justified. The bacteria can produce a potent neurotoxin that causes paralysis and death. There have been only a couple of cases in New Zealand in the last 35 years. The toxin is released when the cells sporulate, so growth of the bacteria is necessary for toxin production. Bacteria cannot grow at the low water activity conditions in whey protein powder, but spores could germinate and grow if infant formula containing the contaminated whey protein were made up and then held warm for some period. The other very serious scenario is that infants fed the contaminated formula might then suffer botulism when the spores grow in the intestinal tract.”
Associate Prof Steve Flint, Associate Professor in Food Microbiology at Massey University, responded to the following questions:
Has there been a botulism outbreak in NZ previously?
“Two confirmed cases were associated with home preserved watercress and boiled mussels back in 1985. ”
How common is food related botulism generally?
“It is rare.”
Fonterra has stated that the contamination came about due to a “dirty pipe“, could you speculate on how this might lead to the bacteria entering the food supply.
“A dirty pipe would not be expected to harbour this organism. This is very unusual.”
What safeguards would typically be in place to prevent contamination events like this?
“This is a very unusual incident and until we know more about how this occurred, it is difficult to offer any advice.”Advertisements